coal and biomass fired boiler reciprocating grate

Industrial boilers

Product thermal capacity: 4-35 t/h

Working pressure: 1.0-2.5 MPA

Outlet temperature: 184-350 ℃

Available fuel: natural gas, coke oven gas, bio-gas,liquid propane gas, diesel, heavy oil, light oil, crude oil

Available industries: Petroleum, chemical, chemical fiber, pharmaceutical, textile printing and dyeing, building materials, wood processing, vegetable oil processing and other industries

  • Product introduction
  • Technical advantages
Introduction

coal and biomass fired boiler reciprocating grate have a three-pass round coil structure. A conical coil is used for the effective protection of the furnace wall at the boiler end. This product is equipped with an advanced combustion device and is fully automated in operation. After the burner ignites the fuel, flame fills the round coil tubes and transfers heat by radiation through the tube wall (first pass). The high temperature flue gas gathers at the back door and then turns to the convection tubes section (second pass), where heat transfer takes place by convection. The flue gas gradually cools down here and flows to the front door, where it is reversed and goes into the third pass. After that, it enters into the chimney through the economizer and is released into the atmosphere.


coal and biomass fired boiler reciprocating grate.This type of heater is delivered as a whole, and is installed on site, it only needs to connect thermal gas(oil) piping and electricity to start operation. The heater has four heating areas: furnace radiation heating area, the first convection tube bundle heating area, the second convection tube bundle heating area and economizer (waste heat boiler).

Digitized manufacture
  • The laying-off of steel tube adopts CNC 3D laser cutting machine.
  • The manufacture of round coil tube adopts CNC coil tube automatic production line. Once-forming and no need for plastic .
Full argon arc welding
  • The tube butt adopts argon arc welding technique and the seams will be done x ray real-time imaging, preventing unqualified seams from entering coil production line .
Easy operation
  • Heater is wholly assembled before delivery, it is easy for installation, debugging and operating.
  • Fully automatic operating, burning, liquid level of high level tank, outlet temperature and flow rate are adjusted automatically and self-protected.
  • The inlet and outlet with end flanges and flanged cover structure facilitate the installation and layout of tubeline in boiler house.
Less fuel consumption
  • Internal side adopts good insulation material, outside uses stainless steel plate, which can mostly reduce heat lost and make working environment better.
  • Multilayers closely spaced tube bundle and steel rod is used to seal and fix, completely eradicating short circuit of flue gas.
  • Before delivery, the residue moisture is removed completely, so the system draining period is reduced to 2 days from 12 days.
Safely operation
  • The inner coil tube has bigger flow rate, so it is more stable under high temperature operation.
  • Conical coil effectively protects the furnace wall at the end of heater and burner on the top.
Boilers Co., LTD - Reciprocating Grate Biomass-fired Ste

Boilers Co., LTD - Reciprocating Grate Biomass-fired Ste

Wuxi Zozen Boilers Co., LTD - China supplier of Reciprocating Grate Biomass-fired Steam Main Products Reciprocating Grate Biomass-fired Steam Last Login

- China Biomass Fired Chain Grate, Coal Reciprocating Gra

- China Biomass Fired Chain Grate, Coal Reciprocating Gra

China International Standard High Quality Biomass Fired Chain Grate, Find details about China Biomass Fired Chain Grate, Coal Reciprocating Grate from

- Detroit Stokers - DSC-GTS Reciprocating Stoker (Biomas

- Detroit Stokers - DSC-GTS Reciprocating Stoker (Biomas

Vertical Fired Burners Packaged Boiler Burners Reciprocating Grate Combustion System technology, of small biomass combustion and gasification systems

Biomass Coal Boiler Reciprocating Step Grate Stoker - Bu

Biomass Coal Boiler Reciprocating Step Grate Stoker - Bu

Biomass Coal Boiler Reciprocating Step Grate Stoker, Find Complete Details about Biomass Coal Boiler Reciprocating Step Grate Stoker,Reciprocating Step Grate

Reciprocating Grates Heat & Mass Balances Boil

Reciprocating Grates Heat & Mass Balances Boil

Fired Heaters, Heat Recovery Equipment, Biomass Grates (Reciprocating, Stationary, Vibrating, Boiler System Repair & Troubleshooting ASME

Reciprocating Grates Heat & Mass Balances Boil

Reciprocating Grates Heat & Mass Balances Boil

and designs based on decades of experience withinFired Heaters, Heat Recovery Equipment, Biomass Reciprocating Grates Heat & Mass Balances Boiler,

Reciprocating Grates Heat & Mass Balances Boil

Reciprocating Grates Heat & Mass Balances Boil

and designs based on decades of experience withinFired Heaters, Heat Recovery Equipment, Biomass Reciprocating Grates Heat & Mass Balances Boiler,

Cost of electricity by source - Wikiped

Cost of electricity by source - Wikiped

coal or oil would double over its present value Biomass Fluidized Bed Boiler 50 MW 122.04 Diesel Reciprocating Engine 212 281 Natural Gas

Burner, Air Reciprocating Biomass Burner Suppliers an

Burner, Air Reciprocating Biomass Burner Suppliers an

Air Reciprocating Biomass Burner, Wholesale Various High Quality Air Reciprocating Biomass Burner Products from Global Air Reciprocating Biomass Burner Suppli

Reciprocating Grate Biomass-fired Steam Boiler of glob

Reciprocating Grate Biomass-fired Steam Boiler of glob

Quality Steam Presses manufacturer, buy high quality Reciprocating Grate Biomass-fired Steam Boiler of Guangzhou New Eye Information & Technology Co., LTD

Reciprocating Grate Biomass-fired Steam Boiler(id:961490

Reciprocating Grate Biomass-fired Steam Boiler(id:961490

Reciprocating Grate Biomass-fired Steam Boiler(id:9614902). View product details of Reciprocating Grate Biomass-fired Steam Boiler from Wuxi

PDFWITHIN A RECIPROCATING GRATE BIOMASS FIRED BOIL

PDFWITHIN A RECIPROCATING GRATE BIOMASS FIRED BOIL

and Italian Sections IFRF and The Combustion Institute NITROGEN OXIDES ABATEMENT NUMERICAL INVESTIGATION WITHIN A RECIPROCATING GRATE BIOMASS FIRED BOILER

Horizontal Reciprocating Grate Bars for Biomass Combustio

Horizontal Reciprocating Grate Bars for Biomass Combustio

Quality Heat-resistant Steel Casting manufacturer, buy high quality Horizontal Reciprocating Grate Bars for Biomass Combustion Machines EB32

Reciprocating grate biomass hot air generator - 168860

Reciprocating grate biomass hot air generator - 168860

Buy Reciprocating grate biomass hot air generator direct from General Industrial Equipment of China Factory that provide Latest General Indu

Smoke Boiler Manufacturer | [email protected]

It can be used on various fuels such as coal,fired boilers in Thailand Biomass Fired Boiler grate, fixed grate, and reciprocating grate. 15

Reciprocating Grate-Type Stoker | Hybrid RG | Hurst Boil

Reciprocating Grate-Type Stoker | Hybrid RG | Hurst Boil

The new HBC reciprocating grate-type stoker system permits biomass fuels with a high proportion of incombustibles to be combusted in an efficient manner

generation plant with reciprocating gas engine and ORC

generation plant with reciprocating gas engine and ORC

generation plant with reciprocating gas engine biomass in the case where there is no heatproducer gas fired engine performance is

PDFWITHIN A RECIPROCATING GRATE BIOMASS FIRED BOIL

PDFWITHIN A RECIPROCATING GRATE BIOMASS FIRED BOIL

and Italian Sections IFRF and The Combustion Institute NITROGEN OXIDES ABATEMENT NUMERICAL INVESTIGATION WITHIN A RECIPROCATING GRATE BIOMASS FIRED BOILER

Smoke Boiler Manufacturer | [email protected]

It can be used on various fuels such as coal,fired boilers in Thailand Biomass Fired Boiler grate, fixed grate, and reciprocating grate. 15

Wiki: Cost of electricity by source - upcScaveng

Wiki: Cost of electricity by source - upcScaveng

coal-fired-generation in many parts of the world Biomass Fluidized Bed Boiler 50MW 122.04 141.Traditional Method Diesel Reciprocating Engine 212

generation plant with reciprocating gas engine and O

generation plant with reciprocating gas engine and O

The paper theoretically investigates the performance of a distributed generation plant made up of gasifier, Internal Combustion Engine (ICE) and Organic